Back to Top

 

 

 

 

 

 

 

Back to Top

 

 

 

 

 

 

 

Back to Top

 

 

 

 

 

 

 

 

Back to Top

 

 

 

 

 

 

 

Back to Top

 

 

 

 

 

 

 

Back to Top

 

 

 

 

 

 

Back to Top

  Limited Nationwide Warranty August (2002)

THIS LIMITED WARRANTY IS IN LIEU OF AND EXCLUDES ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE.

COMPLETE ASSEMBLY/LONG BLOCK (Short Block with heads, assembled by Motor Replacement Co., Inc.) Domestic and Import

PASSENGER CARS (Includes Vans and Pickup Trucks up to & including ton for personal use) are warranted for a period of 36 months or 75,000 miles, whichever occurs first.

TRUCKS (Includes Passenger cars, Vans, and Pickup Trucks in commercial use and Vehicles one ton and over with highway usage, and engines with "RV" suffix on part number ). Are warranted for a period of 24 months or 24,000 miles, whichever occurs first.

MOTOR HOMES AND BUSES are warranted for a period of 12 months or 12,000 miles, whichever occurs first. (Maximum labor adjustment of $750.00 for Motor Homes, applicable only on part numbers designated by The Company for Motor Home use, and $650.00 for bus applications.)

SHORT BLOCKS (Passenger Cars and Trucks) are warranted for a period of 90 days or 4,000 miles, whichever occurs first.

MARINE APPLICATIONS are warranted for a period of 12 months, applicable only on part numbers designated by The Company for marine use.

INDUSTRIAL, STATIONARY, OR OFF ROAD APPLICATIONS (Complete and Short Blocks) are warranted for a period of 45 days, if used for purposes intended by the original manufacturer.

RACE, AND /OR HOT ROD APPLICATIONS are excluded from any and all warranty coverage regardless of cause.

THIS LIMITED WARRANTY COVERS DEFECTIVE WORKMANSHIP OR MATERIALS ASSEMBLED BY US AND IS NOT AN UNCONDITIONAL GUARANTEE AGAINST ALL HAZARDS OR FAILURES. The Company RESERVES THE RIGHT TO CORRECT ANY FAILURES IN SUCH MANNER IT DEEMS NECESSARY AND PROPER.

EXCLUSIONS FROM WARRANTY COVERAGE
Remanufacturer does not warrant against and/or will not pay for or provide, (but not limited to):

(1) Overheating (Heat tab activated, distorted, melted or removed will void this warranty);
(2) Failure due to improper installation, maintenance neglect, abuse, abnormal operations, freezing, or accident;
(3)
Failures due to components not furnished with an engine remanufactured by us or otherwise approved by us for installation, or malfunction of or disconnected engine support system items, or components unsuitable for use with a warranted engine or part;
(4) Internal Engine Damage due to foreign material or failure because of operations causing greater than normal wear, or from use of an engine for purposes other than those for which it was originally intended by the manufacturer;
(5) Damage from detonation /pre-ignition, thermal expansion, or foreign material in combustion chamber;
(6) Valve adjustments, including jet valves;
(7) Crankshaft thrust surface worn due to excessive external pressure;

(8) Replacement labor (except as set forth herein), gaskets, shop supplies or EPA charges, or other items associated with but not including warranted engines and parts;
(9) Towing, vehicle rental, or transportation charges or any other losses incurred in the operation of warranted engines or parts, or incurred due to the failure of warranted engines or parts;
(10) Oil consumption in Short Blocks (Engines purchased without cylinder heads), or any damage due to camshaft failure if new lifters have not been installed;
(11) Bad gas (when gasoline is left in the tank of an idle vehicle for a time long enough to lose its original qualities)
(12) The Company will not be liable for wrong installations due to catalog information, manufacturer changes or engines ordered in error, or repairs to engines in vehicles which the odometer is not operational;
(13) Failure due to old oil-cooler and all external oil lines not being replaced;
(14) Problems due to an engine change (type for type) from the original application;
(15) No labor will be paid for units installed by persons that are not ASE Engine Certified or equivalent certified rating, and in a facility open to the general public for business with a valid business license;
(16) Engines installed in Motor Homes which The Company does not designate for Motor Homes;
(17) Use of any parts not installed by us or not of original equipment application such as performance or special camshafts, carburetion, manifolds, tires not of OEM specifications etc. will void this warranty;
(18) Gaskets and components not installed by the The Company factory are the responsibility of the installer and are not covered under warranty;
(19) Failures caused from engine being operated with any fuel other than gasoline (propane, LPG and etc.), or with turbochargers except when specified by The Company for use with other fuels or turbochargers.
(20) Any repairs prior to having authorization from The Company Customer Service Department in Phoenix, AZ.;

TO ASSURE PROPER PERFORMANCE AND REGISTRATION OF YOUR WARRANTY, THE "CERTIFICATE OF INSTALLATION" MUST BE FULLY COMPLETED AND MAILED TO THE REMANUFACTURER WITH IN (10) DAYS FOLLOWING THE DATE OF INSTALLATION. FAILURE TO RETURN THE COMPLETED CERTIFICATE OF INSTALLATION WILL LIMIT WARRANTY COVERAGE TO 12 MONTHS OR 12,000 MILES WHICHEVER COMES FIRST.

ADDITIONAL LIMITATIONS
Remanufactures liabilities are limited solely and exclusively to repair or replacement of engines or parts within the continental United States according to the terms of this warranty alone and do not include liability for any incidental, consequential damages, lost wages or time, or other damages of any kind whatsoever, whether any claim Is based upon theories of contract negligence or tort.
This warranty may be distributed in a state(s) which may not allow the limitation or exclusion of some warranties or of incidental or consequential damages. In the event that any provision of this warranty should be or become invalid or unenforceable, the remaining terms and conditions hereof shall remain in full force and effect.

ADDITIONAL WARRANTY INFORMATION
To assure a long and satisfactory engine performance be certain the The Company instructions in the Owner's Manual are satisfied, and be sure to follow up with the 500 Mile Service Check, and mail in the "500 Mile Check-up Certificate'. Applications using Propane, L.P.G., or Turbochargers must be special ordered if a listing does not appear in our catalog. The use of standard production units in these applications will result in failure and are not warrantable. If it is determined the failure was caused by defective workmanship or materials assembled by us, Motor Replacement Co., Inc. will make a labor allowance of forty five dollars ($45.00) per hour, based on Motor's Flat Rate / All Data Time Guide. (Do not confuse this with customer retail labor). Maximum adjustment for labor is $650.00 for passenger car and truck. The warranty term commences on the "Date of Installation", which is the date on which the remanufactured engine or part is first installed in, or attached to, or affixed to the vehicle, apparatus, stand, or appliance from or on which it is to be operated by the first buyer for use. Replacement of a warranted engine or part does not extend the warranty term. This limited warranty is transferable provided the "Certificate of Installation" was received by The Company fully completed within 10 days of installation and we receive written notification of the change of vehicle ownership.

THIS IS THE COMPLETE WARRANTY AND NO ONE IS AUTHORIZED TO EXTEND OR ALTER THIS WARRANTY ON BEHALF OF MOTOR REPLACEMENT COMPANY, INC.

INSTALLERS RESPONSIBILITY
(1) The installing mechanic must be ASE Certified (or equivalent) in Engine Repair and Engine Diagnostics.
(2) The installer must follow the Engine Support System Check List and Installation Instructions in the Owner's manual. Failure to do so will void this warranty.
(3) The installer must have vehicle checked to diagnose the status of the Engine Support System (computer, fuel injection, sensors, etc.) to certify it is in proper operating condition before delivery of vehicle to owner (Damage caused to the engine by a malfunctioning support system is not covered by warranty).
(4) The Installer must give the Motor Replacement Co., Inc. warranty and completed installation papers to the vehicle owner.

ADJUSTMENT PROCEDURE
In order to obtain performance of any obligation under this warranty, the vehicle owner should do the following:
(1) Contact the installer who performed the installation.
(2) Have the problem diagnosed without disassembly of The Company product. The Company does not assume liability for wrong diagnosis.
(3) Contact the The Company factory Customer Service Department before proceeding with any repair work.
(A) Communicate nature of problem, part number, work order #, date of installation, mileage,
and invoice #.
(B
) A reference number will be assigned by The Company Customer Service Department for tracking purposes only. It is most important that this reference number be included in all future correspondence.
(4) All parts used for repair must be furnished by The Company unless otherwise directed. (In the event we determine that only in chassis repairs are necessary, we will reimburse the purchaser for that necessary labor in accordance with our published labor schedules for that repair and the cost of necessary parts at jobber cost if not provided by us. Any outside repair work must be guaranteed by the person or company doing the work.
(5) Take reasonable steps to protect the alleged defective engine or part from further use, damage, or contamination.
(6) Return all of the alleged defective engine or part as supplied to the factory (Phoenix, AZ.) for complete factory inspection freight prepaid, unless otherwise instructed by The Company Customer Service. Freight collect shipments will be refused. Any product that is returned by purchaser that The Company Customer Service determines not to be warrantable, or was not originally supplied by The Company will be returned at purchaser's expense.
(7) Factory inspection of alleged defective engine may require complete disassembly of the unit.
(8) If after factory inspection The Company determines the failure was caused by defective workmanship or materials assembled by us, we will reimburse the purchaser for the cost of the replacement engine (providing it was purchased from Motor Replacement Co., Inc.), the cost of labor in accordance with our published labor schedule, the cost of gaskets and parts at jobber cost if not provided by The Company; $15.00 allowance for oil, oil filter and anti-freeze; and freight. No labor will be paid for new return or refunded engine.
(9) When submitting a paid repair order for reimbursement, the following information must be included: (A) Dealer from whom engine was purchased. (B) Reference number, part number, and work order number. (C) Owner's name, mileage, and VIN number (D) Copy of original itemized installation work order.
(10) Your paid repair order must be received by The Company within thirty (30) days after completion of repairs.

Back to Last Page

Products | Quality | About Us | Warranty | Policies | Quote | Line Card | Links | FAQs | Tour | Contact Us | Privacy Statement | Home
© The Company
All Rights Reserved

Arizona Local Search Engine Optimization